Wikipedia

Mangla Dam

The Mangla Dam (Urdu: منگلا بند) is a multipurpose dam situated on the Jhelum River, lying in the Mirpur District of Azad Kashmir and the Jhelum District in Punjab, Pakistan.[1][3] It is the sixth-largest dam in the world. The village of Mangla, which sits at the mouth of the dam, serves as its namesake. In November 1961, the project's selected contractors were revealed; it was announced that Binnie & Partners, a British engineering firm, was going to serve as the lead designers, engineers, and inspectors for the construction of the dam (led by Geoffrey Binnie). The project was undertaken by a consortium known as the Mangla Dam Contractors,[4] which consisted of eight American construction firms sponsored by the Guy F. Atkinson Company based in South San Francisco, California.[5]

Mangla Dam
Aerial photograph of the Mangla Dam, c. 2012
Mangla Dam is located in Pakistan
Mangla Dam
Location of the Mangla Dam within Pakistan
CountryPakistan
LocationMangla, Azad Kashmir
Jhelum, Punjab[1]
Coordinates33°08′31″N 73°38′42″E / 33.142083°N 73.645015°E / 33.142083; 73.645015
StatusOperational
Construction began1961
Opening date1967
Construction costUS$1.5 billion
Owner(s)Government of Pakistan
Operator(s)Water and Power Development Authority (WAPDA)
Dam and spillways
Type of damEmbankment dam
ImpoundsJhelum River
Height147 m (482 ft)
Length3,140 m (10,302 ft)
Reservoir
CreatesMangla Lake
Total capacity9.12 km3 (7,390,000 acre⋅ft)
Catchment area33,334 km2 (12,870 sq mi)
Surface area250 km2 (97 sq mi)
Power Station
Turbines8 x 100 MW
2 x 135 MW
Installed capacity1,070 MW (operational)
1,310 MW (planned)[2]

Background

edit
 
Mangala Dam from the top of Ramkot fortress
 
Picture taken on the Mirpur city side of Lake, near sunset

As part of the Indus Waters Treaty signed in 1960, India gained rights to the waters of the Ravi, Sutlej and Beas rivers, while Pakistan, in addition to the waters of the aforementioned three rivers' sections within Pakistani territory and some monetary compensation, received the rights to develop the Jhelum, Chenab and Indus river basins. Until 1967, the entire irrigation system of Pakistan was fully dependent on unregulated flows of the Indus River and its major tributaries. The agricultural yield was very low for a number of reasons, the most significant being a lack of water during critical growing periods. This problem stemmed from the seasonal variations in river flow due to monsoons and the absence of storage reservoirs to conserve the vast amounts of surplus water during those periods of high river discharge.[6][7]

The Mangla Dam was the first of the two dams constructed to reduce this shortcoming and strengthen the irrigation system of the country as part of the Indus Basin Project, with the other being the Tarbela Dam situated on the Indus River in Swabi, Khyber Pakhtunkhwa.

Construction

edit

Cost

edit

The Mangla Dam was constructed at a cost of ₨1,558.7 billion (US$14.73 billion) with funding being provided by the World Bank and the Asian Development Bank.[8]

 
Engineers of the Mangla Dam Construction Company

Reservoir

edit

The dam was constructed between 1961 and 1965 across the Jhelum River and Poonch River in the Mirpur District of Kashmir, about 108 kilometres (67 mi) southeast of the capital city of Islamabad. The Mangla Dam components include a reservoir, main embankment, intake embankment, main spillway, emergency spillway, intake structures, 5 tunnels, and a power station. Besides the main dam, a dyke called Sukian – 17,000 ft (5,200 m) in length and a small dam called Jari Dam to block the Jari Nala – about 11 miles (18 km) beyond the new Mirpur town had to be constructed.

There was a total of 120 x 106 cubic yards (cu yds) of excavation for the reservoir whereas the total fill amounted to 142 x 106 cu yds and concrete to 1.96 x 106 cu yds respectively. The main embankment is earthfill with clay as the core material. Gravel and A-type sandstone are applied on the shoulders. The maximum height of embankment above the core trench is 454 ft (138 m) and the length is 8,400 ft (2,600 m). The intake embankment is earthfill type with B-type sandstone as the core material. Gravel is applied on the shoulders. The maximum height of the intake embankment above the core trench is 262 ft (80 m) and the length is 1,900 ft (580 m).

Sukian Dam is earthfill with B-type sandstone as the core material. A-type sandstone is applied on the shoulders. The maximum height of the intake embankment above the core trench is 144 ft (44 m) and the length is 16,900 ft (5,200 m).

Jari Dam is also an earthfill type with silt as the core material. Gravel is applied on the shoulders of the dam. The maximum height of Jari dam above the core trench is 274 ft (84 m) and the length is 6,800 ft (2,100 m). The main spillway is a submerged orifice type with 9 radial gates, 36 ft (11 m) x 40 ft (12 m) each; it has a maximum capacity of 1.1 million cusecs. The emergency spillway is a weir type with an erodible bund and a maximum capacity of 0.23 million cusecs. The 5 tunnels are steel and concrete lined and 1,560 feet long in bedrock. The internal diameter ranges between 26 ft (7.9 m) and 31 ft (9.4 m).[9]

Power house

edit

The powerhouse, which consists of turbines, generators, and transformers, has been constructed at the toe of an intake embankment at the ground surface elevation of 865  feet SPD. The water to the powerhouse is supplied through five steel-lined tunnels of 30/26 feet diameter. Each tunnel is designed to feed two generating units. The powerhouse tailrace discharges into New Bong Canal, which has a length of 25,000  feet with a discharge capacity of about 49,000 cusecs, and terminates at an automatic gate control headworks at about 12 km downstream located near old Bong Escape Headworks.[10][11]

 
A view of turbine relief valve operation at Mangla Power House

There are ten vertical Francis type turbines in the powerhouse. Each of these turbines has an output of 138,00 bhp with a rated head of 295 feet of water. The first four turbines were manufactured by Mitsubishi Electric, Japan and were installed in 1969, turbines 5 and 6 are manufactured by ČKD Blansko, the Czech Republic and were installed in 1974, turbines 7-8 were manufactured by ACEC, Belgium and were installed in 1981, while the remaining two turbines are a make of Škoda, Czech Republic and were commissioned in 1994.[12][10]

These turbines are connected to umbrella-type generators which have a generation capacity of 100 MW. Hitachi, Japan had provided generators for turbines 1–4 and 7-8 while Škoda generators are connected to turbines 5-6 and 9–10.

These generators are in turn connected to three-phase transformers. The transformers connected to turbines 1, 4, and 7 were manufactured by the Italy-based Savigliano. The transformers for turbine 5 and 6 are a make of Italtrafo, another Italian company, while the remaining five transformers were provided by Škoda.[10]

Displacement & Resettlement

edit

The Government of Pakistan had agreed to pay royalties to the Government of AJK (Azad Jammu and Kashmir) for the use of the water and electricity generated by the dam. Pakistan initially committed to supplying free electricity to the entire region of Azad Kashmir and providing complimentary clean water to the city of Mirpur. However, over time, this agreement was not transparently upheld, resulting in Pakistan encountering challenges in fulfilling its financial obligations related to royalty payments for electricity and water services in Azad Kashmir. Over 280 villages and the towns of Mirpur and Dadyal were submerged and over 110,000 people were displaced from the area as a result of the dam being built.[13] Some of those affected by the dam were given work permits for Britain by the Government of Pakistan, and as a result, in many cities in the UK the majority of the Pakistani community originates from the Dadyal-Mirpur area of Kashmir.[14] There are 747,000 Mirpuris in the United Kingdom,[15] and the British Mirpuri community forms about 70% of the British Pakistani community. The percentage is greater in northern cities and towns. In Bradford, an industrial town in north-west England, it is estimated that roughly three-quarters of the population is from Mirpur, with a sizeable population also in Birmingham. At the time, many took up work in the textile and steel mills, due to the acute shortage of workers in England.

Operation

edit

The project was designed primarily to increase the amount of water that could be used for irrigation from the flow of the Jhelum and its tributaries. Its secondary function was to generate electrical power from the irrigation releases at the artificial head of the reservoir. The project, though not initially designed as one, also works as a flood control structure by retaining water during the flood-prone season of Monsoon.[14]

On 5 December 1971, the dam was damaged due to a bombing raid conducted by the Indian Air Force during the Indo-Pakistani War of 1971. This was against the international convention that large water reservoirs would not be targeted in war. As a consequence, the hydro project was temporarily out of service.[16][17]

From the data available in 2009, the project had generated 183.551 billion units of low-cost Hydel energy since its commissioning. The annual generation during 2008-2009 was 4797.425 Million KWh while the station shared a peak load of 1150 MW which was 8.18% of the total WAPDA system peak.[10]

On 1 September 2013, the water level in Mangla Dam reached a record height of 1237.15 feet against the maximum conservation level of 1242 feet. Radio Pakistan reported that "the water level in Mangla Dam has attained the maximum height of 1237.15 feet in the history and it is still increasing."[18]

Mangla Dam Raising Project

edit

Mangla reservoir had an initial reservoir capacity of 7.25 billion cubic metres (5.88 million acre-feet), which reduced to 5.77 billion m3 (4.674 million acre⋅ft) in 2005 due to the sedimentation & was likely to reduce further. To counteract this phenomenon, the Mangla Dam Raising Project was started in 2004 and the main dam, spillway and its allied works were completed in 2009 at a cost of Rs. 101.384 billion. This project effectively raised the dam height by 30 feet to 482 feet (147 m), thereby raising the maximum water conservation level from 1202 feet to 1242 feet.[12][19] This increased the dam's storage capacity from 5.56 to 9.12 billion m3 (4.51 to 7.39 million acre⋅ft).[20] Besides, it is expected that after raising the height of the Mangla Dam by 30 feet, the power house will generate 12 percent additional energy per year which will increase its installed capacity from 1,000 MW to 1,120 MW.[21]

The Mangla Dam Raising Project, however, has affected more than 40,000 people living in the vicinity of the dam. The total cost of compensation and resettlement was Rs. 70 billion. The resettlement project includes the construction of New Mirpur City, four satellite towns (Islamgarh, Chakswari, Dadyal, Siakh) with all civic amenities, the Mirpur Bypass and two bridges across River Jehlum and Bong Canal respectively.[9][22]

 
A motorbike passes over the Dhan Galli bridge, a recently constructed bridge on River Jhelum near the Mangla Dam.

Mangla Power House Expansion Project

edit
 
Ambassador Olson with WAPDA Chairman pledging USAID support

The dam was expanded in the era of Pervez Musharraf but it did not enhance the capacity of electric generation except increasing the level of water in the dam.[citation needed] In November 2012, the United States announced a grant of $150 million for the expansion of the Mangla Dam powerhouse. Under the project, $400 million would be spent on the Mangla Dam powerhouse which is estimated to provide additional production for the next 40 years. The project, when complete, will increase the power generation capacity of the Mangla Dam to 1,310 MW from the existing 1,000 MW capacity. WAPDA successfully commissioned two refurbished generating units of the Mangla Hydel Power Station on 23 May 2022, increasing their capacity from 200 MW to 270 MW.[23]

See also

edit

References

edit
  1. ^ a b Kayani, Saheeb-Ahmed (19 July 2012). Mangla Dam Raising Project (Pakistan): General Review and Socio-Spatial Impact Assessment. Islamabad: National University of Sciences and Technology. hal-00719226.
  2. ^ "Mangla Refurbishment Project". nation.com.pk. 24 May 2022. Retrieved 20 July 2023.
  3. ^ Ali, Z.; Shelly, S. Y.; Bibi, F.; Joshua, G.; Khan, A. M.; Khan, B. N.; Akhtar, M. (2011). "Peculiarities of Mangla Reservoir: Biodiversity with sustainable use options" (PDF). The Journal of Animal and Plant Sciences. 21 (2 Suppl.): 372–380. ISSN 1018-7081.372-380&rft.date=2011&rft.issn=1018-7081&rft.aulast=Ali&rft.aufirst=Z.&rft.au=Shelly, S. Y.&rft.au=Bibi, F.&rft.au=Joshua, G.&rft.au=Khan, A. M.&rft.au=Khan, B. N.&rft.au=Akhtar, M.&rft_id=https://thejaps.org.pk/docs/21-2-suppl/JAPS-10(final).pdf&rfr_id=info:sid/en.wikipedia.org:Mangla Dam" class="Z3988">
  4. ^ Muir Wood, Sir Alan (1990). Biographical Memoirs of Fellows of the Royal Society: Geoffrey Morse Binnie (13 November 1908 – 5 April 1989). London: Royal Society. pp. 45–57.45-57&rft.pub=Royal Society&rft.date=1990&rft.aulast=Muir Wood&rft.aufirst=Sir Alan&rfr_id=info:sid/en.wikipedia.org:Mangla Dam" class="Z3988">
  5. ^ Alvi, Hamid. "Two Years of Mangla Dam Project", Trade and Industry: The International Monthly Economic Journal of Pakistan. Spec. issue on Mangla Dam VIII.5 (1964): 633.
  6. ^ "Tarabela Dam". www.structurae.de. Retrieved 9 July 2007.
  7. ^ "Indus Basin Project". Encyclopædia Britannica. Retrieved 9 July 2007.
  8. ^ "Water Dams: Mangla Archived 2013-07-30 at the Wayback Machine". Water & Power Development Authority.this project included Mr Iqbal Hussein and some other workers who did this work with much hardworking. Retrieved 10 August 2013.
  9. ^ a b "Pakistan Water Gateway: Mangla Dam" (PDF). IUCN Pakistan. Archived from the original (PDF) on 22 October 2013. Retrieved 7 August 2013.
  10. ^ a b c d "Hydel Generation: Mangla Dam". Water & Power Development Authority. Archived from the original on 22 October 2013. Retrieved 7 August 2013.
  11. ^ Butt, M. J., Waqas, A., and Mahmood, R. 2010, "The combined effect of Vegetation and Soil Erosion in the Water Resource Management." Water Resource Management. 24(13), 3701-3714, Digital Object Identifier (DOI): 10.1007/s11269-010-9627-7.
  12. ^ a b "UP-GRADATION AND REFURBISHMENT OF GENERATING UNITS OF MANGLA POWER STATION". Water and Power Development Authority. Archived from the original on 10 June 2012. Retrieved 10 September 2013.
  13. ^ Terminski, Bogumil "development-induced Displacement and Resettlement: Theoretical Frameworks and Current Challenges", Indiana University, 2013, available at: http://dlc.dlib.indiana.edu/dlc/handle/10535/8833?show=full
  14. ^ a b "The Pakistani Muslim Community in England" (PDF). Archived from the original (PDF) on 19 September 2012.
  15. ^ "UK Government Web Archive" (PDF). webarchive.nationalarchives.gov.uk. Retrieved 22 November 2024.
  16. ^ "Hunter Aircraft". Global Security.org. Retrieved 9 July 2007.
  17. ^ "Mangla Dam". Pakistanpaedia. Retrieved 7 August 2013.
  18. ^ "Water level in Mangla Dam reaches to record height of 1237.15 feet". Radio Pakistan. 1 September 2013. Archived from the original on 10 September 2013. Retrieved 1 September 2013.
  19. ^ "MANGLA DAM RAISING PROJECT" (PDF). Pakistan Electric Power Company. Archived from the original (PDF) on 4 March 2011. Retrieved 7 August 2013.
  20. ^ "Mangla Dam becomes largest water reservoir of Pakistan". Daily Times (Pakistan). 26 August 2013. Retrieved 10 September 2013.
  21. ^ "Mangla Dam raising to add 120MW". The News International. 22 September 2012. Retrieved 10 September 2013.
  22. ^ "Water storage in Mangla Dam reaches historic high". The Express Tribune. 7 August 2013. Retrieved 10 September 2013.
  23. ^ "Mangla Refurbishment Project". nation.com.pk. 24 May 2022. Retrieved 19 July 2022.
edit
 
Wikimedia Commons has media related to Mangla Dam.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Mangla_Dam&oldid=1264991281"